攪拌車所運輸的混凝土對整個建筑物的質量來說是非常重要的，所以攪拌車司機的責任是非常重大的，在工作中有許多的細節需要掌握，否則不管哪個方面出問題都是非常嚴重的。作為攪拌車的司機要注意一下幾點：

The concrete transported by the mixer is very important to the quality of the whole building, so the responsibility of the mixer driver is very important. There are many details to master in the work, otherwise, no matter what aspect of the problem is very serious. As a mixer driver, pay attention to the following points:

1.攪拌車所運輸的混凝土要保證其質量及塌落度符合混凝土行業的標準及要求。

1. The quality and slump of the concrete transported by the mixer truck shall meet the standards and requirements of the concrete industry.

2.自上料攪拌車在道路上行駛，其上裝的加長料槽要放置在卸料溜槽的支架上并用掛鉤固定好，不允許掛在主排料槽上工作，主卸料槽要旋轉到固定的位置，拉下定位手柄，用鎖緊手柄將彈簧變幅組織鎖緊，避免由于不固定而晃動，造成傷人及其它事故。

2. When the self loading mixer is running on the road, the extended chute installed on it shall be placed on the support of the discharge chute and fixed with hooks. It is not allowed to hang on the main discharge chute for work. The main discharge chute shall be rotated to the fixed position, the positioning handle shall be pulled down, and the spring luffing organization shall be locked with the locking handle to avoid personal injury and other accidents caused by shaking due to non fixation.

3.攪拌車上裝設備連續工作時間不能超過8個小時。

3. The continuous working time of the equipment mounted on the mixer truck shall not exceed 8 hours.

4.自上料攪拌車在混凝土運輸過程中上裝罐體不能停轉，否則會造成混凝土凝結，而且停轉后重新啟動時會對液壓系統和減速機造成沖擊，導致液壓泵和馬達的損壞。

4. The self feeding mixer can not stop loading the tank during concrete transportation, otherwise it will cause concrete condensation, and the hydraulic system and reducer will be impacted when it is restarted after stopping, resulting in damage to the hydraulic pump and motor.

5.攪拌車在卸料的時候，如果發現混凝土水分蒸發過多，塌落度偏低，不能滿足質量要求，可以適當的往罐內加水，然后以10-14轉/分的速度旋轉30分鐘后再卸料，讓混凝土充分攪拌。

5. When the mixer truck is discharging, if it is found that the concrete has too much water evaporation and low slump, which cannot meet the quality requirements, it can add water to the tank properly, and then rotate at the speed of 10-14 rpm for 30 minutes before discharging, so that the concrete can be fully mixed.

6.攪拌車在空載中上裝罐體也不可以停轉，否則在行車過程中車輛的晃動很容易造成滾道和托輪部分磕碰的，這樣托輪和滾道就會過早的損壞。

6. The mixer truck can not be stopped when loading the tank in the empty load, otherwise the rolling way and supporting wheel will be collided easily due to the shaking of the vehicle during driving, so that the supporting wheel and the rolling way will be damaged prematurely.

7.攪拌車駕駛員要記住，在工作過程中壓力水箱的水要常常加滿，備用，在水箱加水前要打開氣閥將內部的空氣放掉，在沖洗車輛后或者停用時要將水箱內的空氣放掉。在冬天，工作結束后要將水箱內的水放掉，不得有剩水，否則容易結冰凍壞水箱。

7. The mixer driver should remember that the water in the pressure water tank should always be filled up for standby during the working process. Before the water tank is filled, the air valve should be opened to drain the air inside, and the air inside the water tank should be drained after washing the vehicle or when it is not used. In winter, the water in the water tank shall be drained after the work is completed, and there shall be no water left, otherwise the water tank may be frozen and damaged.

8.自上料攪拌車在滿載混凝土時罐體正轉，如果需要反轉，就須等罐體停穩后再將手柄扳到反轉位置。

8. When the self feeding mixer truck is fully loaded with concrete, the tank body rotates forward. If it needs to reverse, the handle must be pulled to the reverse position after the tank body stops stably.

攪拌車的行駛環境一般都比較差，所以為了自身安全以及設備完好，合格的攪拌車司機就要做到以上這幾點。更多相關內容就來我們網站http://www.www.boy7up.cn咨詢了解吧！

The driving environment of the mixer is generally poor, so qualified mixer drivers should do the above for their own safety and equipment integrity. More relevant content will come to our website http://www.www.boy7up.cn Ask and understand!