科學地確定各類保養作業的間隔里程，不僅能使自上料攪拌車經常保持良好的技術狀況，還能使您節省保養費用和修理費用。一般技術狀況良好的新車，可適當延長保養周期。而技術狀況較差，或使用條件惡劣的自上料攪拌車，則應適當縮短保養周期。

Scientifically determining the interval mileage of various maintenance operations can not only keep the self-feeding mixer in good technical condition, but also save maintenance and repair costs. The maintenance period can be appropriately extended for new vehicles with good technical conditions. For self-feeding mixer with poor technical conditions or poor service conditions, the maintenance period should be appropriately shortened.

1、每天的保養內容：外觀檢查

1. Daily maintenance content: appearance inspection

在出車前，環視攪拌車，看看燈光裝置有沒有損壞，車身有沒有傾斜，有沒有漏油、漏水等泄漏情況；檢查輪胎的外表情況；檢查車門、發動機倉蓋、行理倉蓋和玻璃的狀況。信號裝置檢查打開點火開關鑰匙（不起動發動機），檢查各報警燈和指示燈的點亮情況，起動發動機查看各報警燈是否正常熄滅，指示燈是否還在點亮。燃油檢查查看油量表的指示，補充燃油。

Before driving out, look around the mixer truck to see if the lighting device is damaged, whether the car body is tilted, and whether there are oil and water leaks; Check the appearance of tyres; Check the condition of the door, engine compartment cover, handling compartment cover and glass. The signal device checks whether the ignition switch key is turned on (the engine is not started), check the illumination of each alarm lamp and indicator lamp, start the engine and check whether each alarm lamp is normally off and whether the indicator lamp is still on. Check the fuel, check the indication of the fuel gauge and replenish the fuel.

2、每周的保養內容：輪胎氣壓

2. Weekly maintenance content: tire pressure

檢查調整輪胎氣壓、清理輪胎上的雜物。不要忘記對備胎的檢查。發動機及各種油液檢查發動機各部件的固定情況，查看發動機各結合面有沒有漏油、漏水的情況；檢查調整皮帶緊度；查看各部位的管路和導線固定情況；檢查補充機油；檢查補充冷卻液；檢查補充電解液；檢查補充動力轉向機油；清潔散熱器外表；補充風擋玻璃清洗液等。清潔汽車內部，清洗汽車外表。

Check and adjust the tire pressure and clean the debris on the tire. Don't forget to check the spare tire. Check the fixing condition of the engine components and check whether there is oil leakage and water leakage on the joint surfaces of the engine; Check and adjust the belt tightness; Check the fixation of pipelines and wires at all parts; Check and replenish the oil; Check and replenish the coolant; Check and replenish the electrolyte; Check and supplement power steering oil; Clean the radiator surface; Replenish windshield washer fluid, etc. Clean the interior and exterior of the car.

3、每月的保養內容：外部檢查

3. Monthly maintenance content: external inspection

巡視攪拌車，檢查燈泡及燈罩的損壞情況；檢查車體飾物的固定情況；檢查倒車鏡的情況。輪胎檢查輪胎的磨損情況，清理行李廂；接近輪胎的磨耗記號時應更換輪胎，檢查輪胎有沒有鼓包、異常主要磨損、老化裂紋和硬傷等情況。清潔打蠟清掃汽車內部；清潔水箱外表、機油散熱器外表和空調散熱器外表上的雜物。底盤檢查底盤有沒有漏油的現象，發現有漏油痕跡，應檢查各總成的齒輪油量并進行適當的補充，對底盤所有的油嘴進行充分的補脂作業。其他細致重復每周的保養內容。

Patrol the mixer and check the damage of the bulb and lamp cover; Check the fixing of the body trims; Check the condition of the reversing mirror. Check the wear of tires and clean the luggage compartment; When approaching the wear mark of the tire, replace the tire and check whether the tire has bulges, abnormal main wear, aging cracks and hard wounds. Clean and wax the interior of the car; Clean the sundries on the surface of water tank, oil radiator and air conditioner radiator. Check the chassis for oil leakage. If there are traces of oil leakage, check the gear oil quantity of each assembly and make appropriate replenishment, and make sufficient grease replenishment for all oil nozzles of the chassis. Repeat the weekly maintenance content carefully.

4、每半年的保養內容：發動機外部

4. Semi-annual maintenance content: engine exterior

清洗發動機外表，清洗時注意對電氣部分的防水處理。如果電氣部分對防水要求較高的話，應避免用高壓、高溫的水槍來沖洗發動機，可以用毛刷沾清洗劑清洗發動機外表。

Clean the exterior of the engine and pay attention to the waterproof treatment of the electrical part during cleaning. If the electrical part has high requirements for waterproof, avoid using high-pressure and high-temperature water guns to wash the engine, and use a brush to dip detergent to clean the engine surface.

5、每年的保養內容：點火正時

5. Annual maintenance content: ignition timing

檢查調整攪拌車發動機的點火正時情況，對柴油機的供油正時的檢查與調整好到修理廠進行。氣門間隙對裝有普通氣門發動機，應檢查高速氣門間隙。清潔潤滑清潔發動機倉蓋，車門和行李倉的鉸接機構的油污，重新調整并潤滑上述機構。

Check and adjust the ignition timing of the mixer engine, and check and adjust the fuel supply timing of the diesel engine at the repair shop. Valve clearance For engines with ordinary valves, check the high-speed valve clearance. Clean, lubricate and clean the oil dirt on the hinge mechanism of the engine compartment cover, door and luggage compartment, readjust and lubricate the above mechanism.

6、每兩年的保養內容：防凍液

6. Maintenance content every two years: antifreeze

防凍液一般的使用年限為兩年，屆時應在年度保養中更換防凍液，并對冷卻系進行清洗。制動系統由于制動系統的吸濕性，制動液每兩年更換一次。

The service life of antifreeze is generally two years. At that time, the antifreeze should be replaced during the annual maintenance and the cooling system should be cleaned. Due to the hygroscopicity of the brake system, the brake fluid is replaced every two years.

以上就是自上料攪拌車保養周期從6個方面來看的相關內容講解了，您對此有怎樣的疑惑或者需求可以隨時來我們網站http://www.www.boy7up.cn進行咨詢！

The above is the explanation of the relevant contents from six aspects of the maintenance cycle of the self-feeding mixer. If you have any doubts or needs about this, please come to our website at any time http://www.www.boy7up.cn Consult!