全自動攪拌車攪拌器的動力由二級底盤的動力提取器通過傳動軸傳遞給液壓泵。液壓泵產生的液壓能量通過油管傳遞給液壓馬達。液壓馬達將液壓能量轉化為動能，通過減速機輸送到攪拌槽。使用一段時間后，過多過少的攪拌桶就會出現攪拌不轉的情況，一般有三種情況:

The power of the mixer of the fully automatic mixer is transmitted to the hydraulic pump through the drive shaft by the power extractor of the secondary chassis. The hydraulic energy generated by the hydraulic pump is transmitted to the hydraulic motor through the oil pipe. The hydraulic motor converts hydraulic energy into kinetic energy and transmits it to the mixing tank through the reducer. After being used for a period of time, too many or too few mixing drums will cause mixing not to turn. Generally, there are three situations:

混凝土在運輸過程中被卡住;

The concrete is stuck during transportation;

液壓系統或發動機故障;

Hydraulic system or engine failure;

馬達出故障了。

The motor is out of order.

1.混凝土在運輸過程中被卡住話，清理干凈就沒有問題了。

1. If the concrete is stuck during transportation, it will be no problem to clean it up.

2.液壓系統或發動機故障處理:

2. Troubleshooting of hydraulic system or engine:

(1)打開攪拌桶人孔蓋，松開馬達上高壓軟管的管接頭，旋轉攪拌桶使攪拌桶人孔斜向下，從攪拌桶人孔排出混凝土;

(1) Open the manhole cover of the mixing drum, loosen the pipe joint of the high-pressure hose on the motor, rotate the mixing drum to make the manhole of the mixing drum incline downward, and discharge the concrete from the manhole of the mixing drum;

(2)麻煩卡車高壓軟管從救濟的電動機用高壓軟管連接到另一端的油泵救援車,后將用于緊急回水管有麻煩卡車機油口、回油管另一端用泵抽油口后救援車輛,使用救援車來控制麻煩卡車的旋轉圓柱,具體的排放。

(2) The high pressure hose of the trouble truck is connected from the relief motor to the oil pump rescue vehicle at the other end with the high pressure hose, and then will be used for the emergency water return pipe with the trouble truck oil port, and the other end of the oil return pipe will be used for the rescue vehicle after the pump oil port, and the rescue vehicle will be used to control the rotating cylinder of the trouble truck, and the specific discharge.

3、電機故障，處理相對簡單，可將電機從救援車上拆下安裝在故障車上，然后將各油管連接起來，啟動救援車時可將混凝土氣缸混出。

3. The treatment of motor fault is relatively simple. The motor can be removed from the rescue vehicle and installed on the fault vehicle, and then the oil pipes can be connected. When starting the rescue vehicle, the concrete cylinder can be mixed out.

全自動攪拌車應遵守交通部養護維修規定，實行“定期檢查、強制養護、視情維修”的養護制度。在這個大前提下，結合全自動攪拌車實際情況，做好養護維修工作。在日常養護方面，車輛應按照汽車發動機、底盤等部件的日常養護，還必須做好相關的養護工作。更多相關內容就來我們網站http://www.www.boy7up.cn咨詢吧！

The fully automatic mixing truck shall comply with the maintenance regulations of the Ministry of Communications and implement the maintenance system of "regular inspection, compulsory maintenance, and maintenance as appropriate". Under this premise, the maintenance work shall be done well in combination with the actual situation of the fully automatic mixer. In terms of daily maintenance, the vehicle shall be maintained according to the daily maintenance of the engine, chassis and other parts of the vehicle, and the relevant maintenance work must be done well. Come to our website for more relevant content http://www.www.boy7up.cn Ask!